APPROVED BY


_____________
'___' ______________ 2020г.
Технологическая инструкция
по производству изделия
Cake From the bottom of my heart
Вырабатывается по
  1. Вводная часть

    Настоящая технологическая инструкция распространяется на производство изделия Cake From the bottom of my heart.

  2. Характеристика готовой продукции

    Качество изделия Cake From the bottom of my heart должно соответствовать требованиям .

  3. Входной контроль сырья

    Получение и контроль входящего сырья на производство, необходимо проверить:

    • наличие медицинской книжки у водителя,
    • температурный режим и состояния кузова,
    • сопроводительные документы (накладная, декларация, качественное удостоверение).
  4. Сырье, применяемое при изготовлении изделия
    1. Перечень сырья
      • Sign up
      • water
      • Starch syrup
      • Fat "Butao-26"
      • Unsalted butter
      • Sign up
      • Whole condensed milk with sugar
      • Flour, premium
      • Fresh whole milk the weight ratio of fat 3.2%
      • Raw egg white
      • Sign up
      • Dry egg white
      • Agar
      • Cocoa powder
      • Citric acid
      • Sign up
      • Vanilla powder
      • Essence
      • Cognac
      • Wine
      • Sign up
      • Vanillin

      Допускается взаимозаменяемость сырья в соответствии с утвержденными указаниями к рецептурам по взаимозаменяемости сырья.

    2. Характеристика сырья

      Sign up

      water
      Transparent liquid, odorless and tasteless. Must meet the requirements of SanPiN 2.1.4.1074-01. "Drinking water. Hygienic requirements for water quality in centralized drinking water supply systems. Quality control".

      Starch syrup
      Depending on the carbohydrate composition, molasses are divided into the following types: low-sugar, caramel acid, caramel enzymatic, maltose, high-sugar. Appearance: thick viscous liquid. It should be transparent, opalescence is allowed for low-sugar and caramel acidic. Taste and smell: Characteristic of molasses, without foreign taste and smell. Mass fraction of reducing substances in terms of dry matter (glucose equivalent) for low-sugar 26-35%, caramel 36-44%, maltose 38-70%, high-sugar more than 45%. The acidity of low-sugar and caramelized acid syrup obtained from potato and other types of tuber starch is not more than 27 degrees, from corn and other types of grain starch is not more than 15 degrees. At the request of the consumer, the mass fraction of molasses dry matter is allowed less than 78%.

      Fat "Butao-26"

      Unsalted butter
      Cow oil should be free of foreign taste, rancidity and odor. Oil with a putrid, rancid, fishy, moldy, musty, greasy taste and smell is not allowed for use.

      Sign up

      Whole condensed milk with sugar
      Taste and smell: The taste is sweet, clean with a pronounced taste and smell of pasteurized milk without foreign tastes and odors. Slight fodder flavor is allowed. Appearance and consistency: Homogeneous, viscous throughout the mass without the presence of organoleptically perceptible crystals of milk sugar (lactose). A mealy consistency and a slight lactose sediment at the bottom of the package during storage are allowed. Color: White with a cream shade. Uniform throughout the mass.

      Flour, premium
      Wheat flour. The color of the higher grades of flour should be white with a yellowish tinge, the lower ones - whiter, darker and non-uniformly variegated. Flour should taste slightly sweet. When chewing flour, there should be no crunch on the teeth, no bitterness and no odors. Flour moisture - no more than 15%

      Fresh whole milk the weight ratio of fat 3.2%
      Whole fresh milk should be free of foreign taste and odor not characteristic of fresh milk.

      Raw egg white
      The egg white should be whitish fawn to yellow-green when frozen and fawn after thawing. There should be no foreign smells and tastes.

      Sign up

      Dry egg white
      Egg white (dry) must be free of foreign taste and smell

      Agar

      Cocoa powder

      Citric acid
      Colorless crystals or white powder without lumps. The taste should be sour, without any foreign aftertaste. There is no smell. The structure should be free-flowing and dry, not sticky to the touch. Mechanical impurities are not allowed.

      Sign up

      Vanilla powder

      Essence

      Cognac

      Wine

      Sign up

      Vanillin

    3. Хранение сырья

      Все сырье и полуфабрикаты, поступающие на склады предприятия, должны соответствовать требованиям действующей НД, сопровождаются документом, удостоверяющим их качество и безопасность, а так же маркировочным ярлыком на каждом тарном месте (ящике, фляге, коробке) с указанием даты изготовления, срока годности или срока хранения.

      На предприятиях должны соблюдаться требования, предъявляемые к хранению продуктов, предотвращающие их порчу.

      Поступившие в производство продукты перекладывают в чистую промаркированную в соответствии с видом продукта производственную тару или хранят в таре поставщика.

      Продукты хранят согласно принятой классификации по условиям хранения.

      Аллергеносодержащее сырье храниться отдельно.

    4. Подготовка сырья к пуску в производство

      Sign up

      water

      Starch syrup
      Starch syrup is heated to 40 -50 ℃ to reduce the viscosity, and then filtered through a sieve with cells of no more than 2 mm.

      Fat "Butao-26"

      Unsalted butter
      The butter is carefully cleaned from the surface, cut into pieces. It is allowed to use oil strippers in the manufacture of baked products. If fats are used in melted form, then they are filtered through a metal sieve with 1.5 mm cells.

      Sign up

      Whole condensed milk with sugar
      Condensed milk is freed from the transport container before being used in production and unpacked and fed to the boiling section, where it is loaded into the digester and heated to a temperature of 85 ℃ for 15-20 minutes. After processing, the condensed milk is filtered through a sieve with cells of no more than 3 mm in diameter. The filtered and cooled condensed milk is placed in clean, dry, labeled containers with tight-fitting lids. Moving in the production of condensed milk in open containers and without marking is prohibited.

      Flour, premium
      Wheat flour is sifted through a sieve with meshes of not more than 2.5 mm and passed through magnetic catchers. If the flour is at a low temperature, then it should be kept in a warm room so that the temperature rises to 12 ℃.

      Fresh whole milk the weight ratio of fat 3.2%
      Fresh whole milk is filtered through a sieve with cells of no more than 1 mm, and then boiled.

      Raw egg white
      Before use, filter the egg white through a sieve with a mesh size of not more than 3 mm.

      Sign up

      Dry egg white

      Agar
      Agar is soaked in running water for 2-4 hours.

      Cocoa powder

      Citric acid
      Dissolve citric acid in hot water (70-80 в) in a 1: 1 ratio and filter through a sieve with cells of no more than 0.5 mm.

      Sign up

      Vanilla powder

      Essence

      Cognac

      Wine

      Sign up

      Vanillin

  5. Описание технологического процесса
    1. Описание процесса изготовления полуфабрикатов:

      Sign up

      No. 104 Jelly

      Agar, previously soaked in running water, is added to the water and heated over low heat with stirring until it is completely dissolved. Then add granulated sugar, molasses and boil for 5-7 minutes until sugar dissolves. The syrup is filtered through a sieve with a mesh size of 1–1.5 mm, cooled to a temperature of 40–50 ℃, and essence, acid and dye are added.
      When preparing jelly for finishing, the hot mass is poured into baking sheets 10–30 mm high and cooled. The resulting jelly is cut into pieces of a certain shape.

      ** Characteristics of a semi-finished product. ** Shiny, translucent, gelatinous mass.

      Sign up

      Sponge cake with surfactant No. 2

      Sign up

      №062а Cream "New" chocolate

      Sign up

      Souffle Lux

    2. Приготовление кондитерского изделия:

      Sign up

  6. Упаковка

  7. Mаркировка, транспортирование и хранение

    Маркировка готовых изделий должна соответствовать Техническим регламентам Таможенного союза ТР ТС 022/2011 «Пищевая продукция в части ее маркировки», ТР ТС 029/2012 "Требования безопасности пищевых добавок, ароматизаторов и технологических вспомогательных средств", ГОСТ Р 53598-2009 «Продукты пищевые. Рекомендации по этикетированию»

    Состав: white sugar, molasses or glucose syrup, fat "Butao-26", unsalted butter, melange, whole condensed milk with sugar, flour, premium, fresh whole milk the weight ratio of fat 3.2%, raw egg white, surfactant (churning paste) (water, sugar, emulsifier E471, preservative E202), dry egg white, thickener - agar, cocoa powder, acidity regulator - citric acid, flavoring, vanilla powder, essence, cognac, wine, food paint, vanillin.

    Состав: white sugar, molasses or glucose syrup, fat "Butao-26", unsalted butter, melange, whole condensed milk with sugar, flour, premium, fresh whole milk the weight ratio of fat 3.2%, raw egg white, surfactant (churning paste) (water, sugar, emulsifier E471, preservative E202), dry egg white, thickener - E406, cocoa powder, acidity regulator - E330, flavoring, vanilla powder, essence, cognac, wine, food paint, vanillin.

  8. Контроль производства

    На протяжении всего технологического процесса производства кондитерского изделия Cake From the bottom of my heart проводят контроль за соблюдением технологических параметров, качества используемого сырья, материалов, готовой продукции. Готовый продукт подлежит выборочному контролю качества, с записью результатов в журнал.

  9. Требования безопасности производства

    Технологический процесс должен соответствовать требованиям техники безопасности и типовым инструкция по охране труда для работников предприятий торговли и общественного питания.

Приложение

Перечень нормативных документов

  • Sign up
  • ГОСТ 16280-2002 Agar food. Technical conditions.
  • Sign up
  • ГОСТ 26574-2017 Wheat baking flour. Technical conditions
  • Sign up
  • ГОСТ 30363-2013 Liquid and dry food egg products. Technical conditions
  • Sign up
  • ГОСТ 31688-2012 Dairy canned food. Condensed milk and cream with sugar. Technical conditions
  • Sign up
  • ГОСТ 31732-2014 Cognac. General specifications
  • Sign up
  • ГОСТ 32261-2013 Butter. Technical conditions
  • Sign up
  • ГОСТ 33806-2016 Fruit table wines and fruit table wine materials. General specifications
  • Sign up
  • ГОСТ 908-2004 Citric acid monohydrate food. Technical conditions
  • Sign up
  • СанПиН 2.1.4.1074-01 Drinking water Hygienic requirements for water quality in centralized drinking water supply systems. Quality control.
  • Sign up