APPROVED BY


_____________
'___' ______________ 2020г.
Технологическая инструкция
по производству изделия
Rhythm Cake [Shatura]
Вырабатывается по
  1. Вводная часть

    Настоящая технологическая инструкция распространяется на производство изделия Rhythm Cake [Shatura].

  2. Характеристика готовой продукции

    Качество изделия Rhythm Cake [Shatura] должно соответствовать требованиям .

  3. Входной контроль сырья

    Получение и контроль входящего сырья на производство, необходимо проверить:

    • наличие медицинской книжки у водителя,
    • температурный режим и состояния кузова,
    • сопроводительные документы (накладная, декларация, качественное удостоверение).
  4. Сырье, применяемое при изготовлении изделия
    1. Перечень сырья
      • Sign up
      • Unsalted butter
      • Starch syrup
      • Water
      • Whole condensed milk with sugar
      • Sign up
      • Melange
      • Flour, premium
      • Chocolate
      • Potato starch
      • Sign up
      • Citric acid
      • Citrus essence
      • Essence
      • Vanilla powder
      • Sign up

      Допускается взаимозаменяемость сырья в соответствии с утвержденными указаниями к рецептурам по взаимозаменяемости сырья.

    2. Характеристика сырья

      Sign up

      Unsalted butter
      Cow oil should be free of foreign taste, rancidity and odor. Oil with a putrid, rancid, fishy, moldy, musty, greasy taste and smell is not allowed for use.

      Starch syrup
      Depending on the carbohydrate composition, molasses are divided into the following types: low-sugar, caramel acid, caramel enzymatic, maltose, high-sugar. Appearance: thick viscous liquid. It should be transparent, opalescence is allowed for low-sugar and caramel acidic. Taste and smell: Characteristic of molasses, without foreign taste and smell. Mass fraction of reducing substances in terms of dry matter (glucose equivalent) for low-sugar 26-35%, caramel 36-44%, maltose 38-70%, high-sugar more than 45%. The acidity of low-sugar and caramelized acid syrup obtained from potato and other types of tuber starch is not more than 27 degrees, from corn and other types of grain starch is not more than 15 degrees. At the request of the consumer, the mass fraction of molasses dry matter is allowed less than 78%.

      Water
      Transparent liquid, odorless and tasteless. Must meet the requirements of SanPiN 2.1.4.1074-01. "Drinking water. Hygienic requirements for water quality in centralized drinking water supply systems. Quality control".

      Whole condensed milk with sugar
      Taste and smell: The taste is sweet, clean with a pronounced taste and smell of pasteurized milk without foreign tastes and odors. Slight fodder flavor is allowed. Appearance and consistency: Homogeneous, viscous throughout the mass without the presence of organoleptically perceptible crystals of milk sugar (lactose). A mealy consistency and a slight lactose sediment at the bottom of the package during storage are allowed. Color: White with a cream shade. Uniform throughout the mass.

      Sign up

      Melange
      Melange should be dark orange when frozen and light yellow to light orange after thawing. There should be no foreign smells and tastes.

      Flour, premium
      Wheat flour. The color of the higher grades of flour should be white with a yellowish tinge, the lower ones - whiter, darker and non-uniformly variegated. Flour should taste slightly sweet. When chewing flour, there should be no crunch on the teeth, no bitterness and no odors. Flour moisture - no more than 15%

      Chocolate

      Potato starch
      Appearance: homogeneous powdery product. The color of the highest grades of starch is white, the second grade is white with a grayish tint. Smell: characteristic of starch, no foreign smell.

      Sign up

      Citric acid
      Colorless crystals or white powder without lumps. The taste should be sour, without any foreign aftertaste. There is no smell. The structure should be free-flowing and dry, not sticky to the touch. Mechanical impurities are not allowed.

      Citrus essence

      Essence

      Vanilla powder

      Sign up

    3. Хранение сырья

      Все сырье и полуфабрикаты, поступающие на склады предприятия, должны соответствовать требованиям действующей НД, сопровождаются документом, удостоверяющим их качество и безопасность, а так же маркировочным ярлыком на каждом тарном месте (ящике, фляге, коробке) с указанием даты изготовления, срока годности или срока хранения.

      На предприятиях должны соблюдаться требования, предъявляемые к хранению продуктов, предотвращающие их порчу.

      Поступившие в производство продукты перекладывают в чистую промаркированную в соответствии с видом продукта производственную тару или хранят в таре поставщика.

      Продукты хранят согласно принятой классификации по условиям хранения.

      Аллергеносодержащее сырье храниться отдельно.

    4. Подготовка сырья к пуску в производство

      Sign up

      Unsalted butter
      The butter is carefully cleaned from the surface, cut into pieces. It is allowed to use oil strippers in the manufacture of baked products. If fats are used in melted form, then they are filtered through a metal sieve with 1.5 mm cells.

      Starch syrup
      Starch syrup is heated to 40 -50 ℃ to reduce the viscosity, and then filtered through a sieve with cells of no more than 2 mm.

      Water

      Whole condensed milk with sugar
      Condensed milk is freed from the transport container before being used in production and unpacked and fed to the boiling section, where it is loaded into the digester and heated to a temperature of 85 ℃ for 15-20 minutes. After processing, the condensed milk is filtered through a sieve with cells of no more than 3 mm in diameter. The filtered and cooled condensed milk is placed in clean, dry, labeled containers with tight-fitting lids. Moving in the production of condensed milk in open containers and without marking is prohibited.

      Sign up

      Melange
      Before being fed into production, frozen melange is pre-thawed in baths with water or special chambers at a temperature not exceeding 45 ℃ and filtered through a sieve with a mesh size of not more than 3 mm. For products in which whole milk or water is used when kneading the dough, the melange can be mixed with them in a 1: 1 ratio before straining. Thawed egg products should be used within 3-4 hours.

      Flour, premium
      Wheat flour is sifted through a sieve with meshes of not more than 2.5 mm and passed through magnetic catchers. If the flour is at a low temperature, then it should be kept in a warm room so that the temperature rises to 12 ℃.

      Chocolate

      Potato starch

      Sign up

      Citric acid
      Dissolve citric acid in hot water (70-80 в) in a 1: 1 ratio and filter through a sieve with cells of no more than 0.5 mm.

      Citrus essence

      Essence

      Vanilla powder

      Sign up

  5. Описание технологического процесса
    1. Описание процесса изготовления полуфабрикатов:

      Sign up

      №085 Protein cream on agar

      Prepare a cream like protein on agar No. 83. At the end of whipping, add vanillin and citric acid.

      Sign up

      No. 098 Sugar-agar syrup

      Granulated sugar and water in a ratio of 4: 1 are boiled to a temperature of 120 ℃, agar is added, previously soaked in running water for 3-4 hours, heated over low heat with stirring until the agar is completely dissolved and molasses is added, after which the syrup is heated to 118 ℃.

      Sign up

    2. Приготовление кондитерского изделия:

      Sign up

  6. Упаковка

  7. Mаркировка, транспортирование и хранение

    Маркировка готовых изделий должна соответствовать Техническим регламентам Таможенного союза ТР ТС 022/2011 «Пищевая продукция в части ее маркировки», ТР ТС 029/2012 "Требования безопасности пищевых добавок, ароматизаторов и технологических вспомогательных средств", ГОСТ Р 53598-2009 «Продукты пищевые. Рекомендации по этикетированию»

    Состав: white sugar, unsalted butter, molasses or glucose syrup, whole condensed milk with sugar, raw egg white, melange, flour, premium, chocolate, potato starch, thickener - agar, acidity regulator - citric acid, citrus essence, essence, vanilla powder, vanillin.

    Состав: white sugar, unsalted butter, molasses or glucose syrup, whole condensed milk with sugar, raw egg white, melange, flour, premium, chocolate, potato starch, thickener - E406, acidity regulator - E330, citrus essence, essence, vanilla powder, vanillin.

  8. Контроль производства

    На протяжении всего технологического процесса производства кондитерского изделия Rhythm Cake [Shatura] проводят контроль за соблюдением технологических параметров, качества используемого сырья, материалов, готовой продукции. Готовый продукт подлежит выборочному контролю качества, с записью результатов в журнал.

  9. Требования безопасности производства

    Технологический процесс должен соответствовать требованиям техники безопасности и типовым инструкция по охране труда для работников предприятий торговли и общественного питания.

Приложение

Перечень нормативных документов

  • Sign up
  • ГОСТ 16599-71 Vanillin. Technical conditions.
  • Sign up
  • ГОСТ 30363-2013 Liquid and dry food egg products. Technical conditions
  • Sign up
  • ГОСТ 31721-2012 Chocolate. General specifications
  • Sign up
  • ГОСТ 32261-2013 Butter. Technical conditions
  • Sign up
  • ГОСТ 33917-2016 Starch syrup. General specifications
  • Sign up
  • ГОСТ Р 53876-2010 Potato starch. Technical conditions
  • Sign up