APPROVED BY


_____________
'___' ______________ 2020г.
Технологическая инструкция
по производству изделия
Olga cake [Lyubertsy]
Вырабатывается по
  1. Вводная часть

    Настоящая технологическая инструкция распространяется на производство изделия Olga cake [Lyubertsy].

  2. Характеристика готовой продукции

    Качество изделия Olga cake [Lyubertsy] должно соответствовать требованиям .

  3. Входной контроль сырья

    Получение и контроль входящего сырья на производство, необходимо проверить:

    • наличие медицинской книжки у водителя,
    • температурный режим и состояния кузова,
    • сопроводительные документы (накладная, декларация, качественное удостоверение).
  4. Сырье, применяемое при изготовлении изделия
    1. Перечень сырья
      • Sign up
      • Unsalted butter
      • Chocolate
      • Raw egg white
      • Starch syrup
      • Sign up
      • Whole condensed milk with sugar
      • Fresh whole milk the weight ratio of fat 3.2%
      • Cocoa powder
      • Vanilla powder
      • Sign up
      • Citric acid
      • Citrus essence
      • Cognac
      • Wine
      • Sign up

      Допускается взаимозаменяемость сырья в соответствии с утвержденными указаниями к рецептурам по взаимозаменяемости сырья.

    2. Характеристика сырья

      Sign up

      Unsalted butter
      Cow oil should be free of foreign taste, rancidity and odor. Oil with a putrid, rancid, fishy, moldy, musty, greasy taste and smell is not allowed for use.

      Chocolate

      Raw egg white
      The egg white should be whitish fawn to yellow-green when frozen and fawn after thawing. There should be no foreign smells and tastes.

      Starch syrup
      Depending on the carbohydrate composition, molasses are divided into the following types: low-sugar, caramel acid, caramel enzymatic, maltose, high-sugar. Appearance: thick viscous liquid. It should be transparent, opalescence is allowed for low-sugar and caramel acidic. Taste and smell: Characteristic of molasses, without foreign taste and smell. Mass fraction of reducing substances in terms of dry matter (glucose equivalent) for low-sugar 26-35%, caramel 36-44%, maltose 38-70%, high-sugar more than 45%. The acidity of low-sugar and caramelized acid syrup obtained from potato and other types of tuber starch is not more than 27 degrees, from corn and other types of grain starch is not more than 15 degrees. At the request of the consumer, the mass fraction of molasses dry matter is allowed less than 78%.

      Sign up

      Whole condensed milk with sugar
      Taste and smell: The taste is sweet, clean with a pronounced taste and smell of pasteurized milk without foreign tastes and odors. Slight fodder flavor is allowed. Appearance and consistency: Homogeneous, viscous throughout the mass without the presence of organoleptically perceptible crystals of milk sugar (lactose). A mealy consistency and a slight lactose sediment at the bottom of the package during storage are allowed. Color: White with a cream shade. Uniform throughout the mass.

      Fresh whole milk the weight ratio of fat 3.2%
      Whole fresh milk should be free of foreign taste and odor not characteristic of fresh milk.

      Cocoa powder

      Vanilla powder

      Sign up

      Citric acid
      Colorless crystals or white powder without lumps. The taste should be sour, without any foreign aftertaste. There is no smell. The structure should be free-flowing and dry, not sticky to the touch. Mechanical impurities are not allowed.

      Citrus essence

      Cognac

      Wine

      Sign up

    3. Хранение сырья

      Все сырье и полуфабрикаты, поступающие на склады предприятия, должны соответствовать требованиям действующей НД, сопровождаются документом, удостоверяющим их качество и безопасность, а так же маркировочным ярлыком на каждом тарном месте (ящике, фляге, коробке) с указанием даты изготовления, срока годности или срока хранения.

      На предприятиях должны соблюдаться требования, предъявляемые к хранению продуктов, предотвращающие их порчу.

      Поступившие в производство продукты перекладывают в чистую промаркированную в соответствии с видом продукта производственную тару или хранят в таре поставщика.

      Продукты хранят согласно принятой классификации по условиям хранения.

      Аллергеносодержащее сырье храниться отдельно.

    4. Подготовка сырья к пуску в производство

      Sign up

      Unsalted butter
      The butter is carefully cleaned from the surface, cut into pieces. It is allowed to use oil strippers in the manufacture of baked products. If fats are used in melted form, then they are filtered through a metal sieve with 1.5 mm cells.

      Chocolate

      Raw egg white
      Before use, filter the egg white through a sieve with a mesh size of not more than 3 mm.

      Starch syrup
      Starch syrup is heated to 40 -50 ℃ to reduce the viscosity, and then filtered through a sieve with cells of no more than 2 mm.

      Sign up

      Whole condensed milk with sugar
      Condensed milk is freed from the transport container before being used in production and unpacked and fed to the boiling section, where it is loaded into the digester and heated to a temperature of 85 ℃ for 15-20 minutes. After processing, the condensed milk is filtered through a sieve with cells of no more than 3 mm in diameter. The filtered and cooled condensed milk is placed in clean, dry, labeled containers with tight-fitting lids. Moving in the production of condensed milk in open containers and without marking is prohibited.

      Fresh whole milk the weight ratio of fat 3.2%
      Fresh whole milk is filtered through a sieve with cells of no more than 1 mm, and then boiled.

      Cocoa powder

      Vanilla powder

      Sign up

      Citric acid
      Dissolve citric acid in hot water (70-80 в) in a 1: 1 ratio and filter through a sieve with cells of no more than 0.5 mm.

      Citrus essence

      Cognac

      Wine

      Sign up

  5. Описание технологического процесса
    1. Описание процесса изготовления полуфабрикатов:

      Sign up

      No. 063 Milk-sugar syrup

      Milk is poured into the boiler, granulated sugar is added. The mixture is thoroughly mixed and boiled for 3-5 minutes to a temperature of 104-105 ℃ (test per thin thread). Milk-sugar syrup is filtered through a sieve with a mesh size of 1.5 mm and cooled.

      Sign up

      No. 098 Sugar-agar syrup

      Granulated sugar and water in a ratio of 4: 1 are boiled to a temperature of 120 ℃, agar is added, previously soaked in running water for 3-4 hours, heated over low heat with stirring until the agar is completely dissolved and molasses is added, after which the syrup is heated to 118 ℃.

      Sign up

      №062 Cream "New" chocolate

      Prepared as a cream New No. 61, at the end of whipping add cocoa powder.

      ** Characteristics of a semi-finished product. ** Homogeneous fluffy mass of brown color, with a glossy surface, well retaining its shape.

      Sign up

      №105 Souffle

      Hot sugar-agar syrup is introduced in a thin stream into the egg whites, beaten for 15–20 minutes, and beating is continued until a fluffy mass is obtained.
      At the end of whipping, add a prepared homogeneous mixture of softened butter, condensed milk, citrus essence and stop whipping immediately.

      ** Characteristics of a semi-finished product. ** A thick, fluffy mass of white color, well retaining its shape.

    2. Приготовление кондитерского изделия:

      Sign up

  6. Упаковка

  7. Mаркировка, транспортирование и хранение

    Маркировка готовых изделий должна соответствовать Техническим регламентам Таможенного союза ТР ТС 022/2011 «Пищевая продукция в части ее маркировки», ТР ТС 029/2012 "Требования безопасности пищевых добавок, ароматизаторов и технологических вспомогательных средств", ГОСТ Р 53598-2009 «Продукты пищевые. Рекомендации по этикетированию»

    Состав: white sugar, unsalted butter, chocolate, raw egg white, molasses or glucose syrup, whole condensed milk with sugar, fresh whole milk the weight ratio of fat 3.2%, cocoa powder, vanilla powder, thickener - agar, acidity regulator - citric acid, citrus essence, cognac, wine, essence.

    Состав: white sugar, unsalted butter, chocolate, raw egg white, molasses or glucose syrup, whole condensed milk with sugar, fresh whole milk the weight ratio of fat 3.2%, cocoa powder, vanilla powder, thickener - E406, acidity regulator - E330, citrus essence, cognac, wine, essence.

  8. Контроль производства

    На протяжении всего технологического процесса производства кондитерского изделия Olga cake [Lyubertsy] проводят контроль за соблюдением технологических параметров, качества используемого сырья, материалов, готовой продукции. Готовый продукт подлежит выборочному контролю качества, с записью результатов в журнал.

  9. Требования безопасности производства

    Технологический процесс должен соответствовать требованиям техники безопасности и типовым инструкция по охране труда для работников предприятий торговли и общественного питания.

Приложение

Перечень нормативных документов

  • Sign up
  • ГОСТ 32261-2013 Butter. Technical conditions
  • Sign up
  • ГОСТ 30363-2013 Liquid and dry food egg products. Technical conditions
  • Sign up
  • СанПиН 2.1.4.1074-01 Drinking water Hygienic requirements for water quality in centralized drinking water supply systems. Quality control.
  • Sign up
  • ГОСТ 31450-2013 Drinking milk. Technical conditions
  • Sign up
  • ГОСТ 16280-2002 Agar food. Technical conditions.
  • Sign up
  • ГОСТ 908-2004 Citric acid monohydrate food. Technical conditions
  • Sign up
  • ГОСТ 33806-2016 Fruit table wines and fruit table wine materials. General specifications
  • Sign up