1. Вводная часть

   Настоящая технологическая инструкция распространяется на производство изделия Butterfly cake [Voskresensk].

2. Характеристика готовой продукции

   Качество изделия Butterfly cake [Voskresensk] должно соответствовать требованиям .

3. Входной контроль сырья

   Получение и контроль входящего сырья на производство, необходимо проверить:

   • наличие медицинской книжки у водителя,
   • температурный режим и состояния кузова,
   • сопроводительные документы (накладная, декларация, качественное удостоверение).
4. Сырье, применяемое при изготовлении изделия
   1. Перечень сырья
      • Sign up
      • white sugar
      • water
      • butter
      • melange
      • Sign up
      • molasses or glucose syrup
      • fresh whole milk the weight ratio of fat 3.2%
      • whole condensed milk with sugar the weight ratio of fat 8.5%
      • raw egg white
      • Sign up
      • ammonium carbonate
      • cocoa powder
      • agar
      • citric acid
      • Sign up
      • vanilla powder
      • citrus essence
      • sodium hydrogen carbonate
      • essence of rum
      • Sign up
      • wine

      Допускается взаимозаменяемость сырья в соответствии с утвержденными указаниями к рецептурам по взаимозаменяемости сырья.

   2. Характеристика сырья

      Sign up

      White sugar
      Sugar sand should have a sweet taste without any extraneous taste and odor, be free-flowing, not sticky, and dry to the touch, completely soluble in water, not contain lumps of whitened sugar, sticky crystals and impurities, have a white color and not contain moisture more than 0.14%.

      Water
      Transparent liquid, odorless and tasteless.

      Butter
      Butter made from cow's milk and/or dairy products and by-products of milk processing, intended for direct consumption, culinary purposes and use in other food industries. Taste and smell: expressed or insufficiently expressed creamy and aftertaste of pasteurization, without extraneous aftertastes and smells. Consistency: dense, plastic, homogeneous, shiny or slightly matte on the cut. Color: from light yellow to yellow, uniform throughout the mass.

      Melange
      Melange should be dark orange when frozen and light yellow to light orange after thawing. There should be no foreign smells and tastes.

      Sign up

      Molasses or glucose syrup
      Depending on the carbohydrate composition, molasses are divided into the following types: low-sugar, caramel acid, caramel enzymatic, maltose, high-sugar. Appearance: thick viscous liquid. It should be transparent, opalescence is allowed for low-sugar and caramel acidic. Taste and smell: Characteristic of molasses, without foreign taste and smell. Mass fraction of reducing substances in terms of dry matter (glucose equivalent) for low-sugar 26-35%, caramel 36-44%, maltose 38-70%, high-sugar more than 45%. The acidity of low-sugar and caramelized acid syrup obtained from potato and other types of tuber starch is not more than 27 degrees, from corn and other types of grain starch is not more than 15 degrees. At the request of the consumer, the mass fraction of molasses dry matter is allowed less than 78%.

      Fresh whole milk the weight ratio of fat 3.2%
      Whole fresh milk should be free of foreign taste and odor not characteristic of fresh milk.

      Whole condensed milk with sugar the weight ratio of fat 8.5%
      Taste and smell: The taste is sweet, clean with a pronounced taste and smell of pasteurized milk without foreign tastes and odors. Slight fodder flavor is allowed. Appearance and consistency: Homogeneous, viscous throughout the mass without the presence of organoleptically perceptible crystals of milk sugar (lactose). A mealy consistency and a slight lactose sediment at the bottom of the package during storage are allowed. Color: White with a cream shade. Uniform throughout the mass.

      Raw egg white
      The egg white should be whitish fawn to yellow-green when frozen and fawn after thawing. There should be no foreign smells and tastes.

      Sign up

      Ammonium carbonate
      Ammonium carbonate is a dense lump of crystals that can be easily broken into powder. Crystals can be white, colorless, slightly pinkish, gray. The reagent is volatile, has a characteristic smell of ammonia, because already at room temperature begins to decompose, giving off NH3 (ammonia). Water-soluble, soluble in alcohol and glycerin, unstable when heated, in contact with air, in solution. Should be stored in an airtight container in a cool dry place, preferably in containers protected from light.

      Cocoa powder
      Finely ground cocoa cake, remaining after partial removal of butter from the cocoa mass, with the addition of various flavors and aromas. Appearance: finely divided, homogeneous powder from light to dark brown. Dull gray tint is not allowed. Taste and aroma are characteristic of cocoa powder: pleasant, bitter, well-expressed, without foreign tastes and odors.

      Agar
      

      Citric acid
      Colorless crystals or white powder without lumps. The taste should be sour, without any foreign aftertaste. There is no smell. The structure should be free-flowing and dry, not sticky to the touch. Mechanical impurities are not allowed.

      Sign up

      Vanilla powder
      

      Citrus essence
      

      Sodium hydrogen carbonate
      White crystalline powder, odorless.

      Essence of rum
      

      Sign up

      Wine
      

   3. Хранение сырья

      Все сырье и полуфабрикаты, поступающие на склады предприятия, должны соответствовать требованиям действующей НД, сопровождаются документом, удостоверяющим их качество и безопасность, а так же маркировочным ярлыком на каждом тарном месте (ящике, фляге, коробке) с указанием даты изготовления, срока годности или срока хранения.

      На предприятиях должны соблюдаться требования, предъявляемые к хранению продуктов, предотвращающие их порчу.

      Поступившие в производство продукты перекладывают в чистую промаркированную в соответствии с видом продукта производственную тару или хранят в таре поставщика.

      Продукты хранят согласно принятой классификации по условиям хранения.

      Аллергеносодержащее сырье храниться отдельно.

   4. Подготовка сырья к пуску в производство

      Sign up

      White sugar
      Sugar, used in the production in dry form, is sieved through a sieve with a mesh size of not more than 3 mm and passed through magnetic traps. Sugar used for the preparation of syrup is sieved, dissolved in water, and the resulting sugar syrup is filtered through a metal sieve with a mesh size of not more than 1.5 mm.

      Water
      

      Butter
      When unpacking, it is carefully checked for the absence of foreign objects. The surface of the oil is cleaned in a special room on metal tables. Stands up to a temperature of 8-10 degrees. C. Before use, the oil is cut into pieces and carefully examined. Intra-workshop transportation of unpacked oil is carried out in a clean, closed production container. It is allowed to use oil strippings in the manufacture of baked products. If the fats are used in melted form, then they are filtered through a metal sieve with a mesh size of 1.5 mm.

      Melange
      Before being fed into production, frozen melange is pre-thawed in baths with water or special chambers at a temperature not exceeding 45 ℃ and filtered through a sieve with a mesh size of not more than 3 mm. For products in which whole milk or water is used when kneading the dough, the melange can be mixed with them in a 1: 1 ratio before straining. Thawed egg products should be used within 3-4 hours.

      Sign up

      Molasses or glucose syrup
      Starch syrup is heated to 40 -50 ℃ to reduce the viscosity, and then filtered through a sieve with cells of no more than 2 mm.

      Fresh whole milk the weight ratio of fat 3.2%
      Fresh whole milk is filtered through a sieve with cells of no more than 1 mm, and then boiled.

      Whole condensed milk with sugar the weight ratio of fat 8.5%
      Condensed milk is freed from the transport container before being used in production and unpacked and fed to the boiling section, where it is loaded into the digester and heated to a temperature of 85 ℃ for 15-20 minutes. After processing, the condensed milk is filtered through a sieve with cells of no more than 3 mm in diameter. The filtered and cooled condensed milk is placed in clean, dry, labeled containers with tight-fitting lids. Moving in the production of condensed milk in open containers and without marking is prohibited.

      Raw egg white
      Before use, filter the egg white through a sieve with a mesh size of not more than 3 mm.

      Sign up

      Ammonium carbonate
      Ammonium carbonate is preliminarily crushed to a powdery state, sieved through sieves with cells of 1.5-2.0 mm or dissolved in water with a temperature of 20 degrees and filtered through sieves with cells of 0.5 mm.

      Cocoa powder
      Sieve through a sieve with cells of 1-1.5 mm.

      Agar
      Agar is soaked in running water for 2-4 hours.

      Citric acid
      Dissolve citric acid in hot water (70-80 в) in a 1: 1 ratio and filter through a sieve with cells of no more than 0.5 mm.

      Sign up

      Vanilla powder
      

      Citrus essence
      

      Sodium hydrogen carbonate
      Baking soda is sieved through a sieve or dissolved in cold water and filtered.

      Essence of rum
      

      Sign up

      Wine
      

5. Описание технологического процесса
   1. Описание процесса изготовления полуфабрикатов:

      Sign up

      No. 063 Milk-sugar syrup
      

      Milk is poured into the boiler, granulated sugar is added. The mixture is thoroughly mixed and boiled for 3-5 minutes to a temperature of 104-105 ℃ (test per thin thread). Milk-sugar syrup is filtered through a sieve with a mesh size of 1.5 mm and cooled.

      Sign up

      No. 095 Blotting syrup
      

      Granulated sugar and water in a ratio of 1: 1.1 are boiled with constant stirring, removing the foam that appears during boiling. The syrup is boiled down to a density of 1.22–1.25 (medium syrup), cooled to 20 ℃, filtered and rum essence and cognac or dessert wine are added.

      ** Characteristics of the semi-finished product. ** Transparent viscous syrup with the smell of essence, wine or cognac.

      Sign up

      №105 Souffle
      

      Hot sugar-agar syrup is introduced in a thin stream into the egg whites, beaten for 15–20 minutes, and beating is continued until a fluffy mass is obtained.
      At the end of whipping, add a prepared homogeneous mixture of softened butter, condensed milk, citrus essence and stop whipping immediately.

      ** Characteristics of a semi-finished product. ** A thick, fluffy mass of white color, well retaining its shape.

      Sign up

   2. Приготовление кондитерского изделия:

      Sign up

6. Упаковка

7. Mаркировка, транспортирование и хранение

   Маркировка готовых изделий должна соответствовать Техническим регламентам Таможенного союза ТР ТС 022/2011 «Пищевая продукция в части ее маркировки», ТР ТС 029/2012 "Требования безопасности пищевых добавок, ароматизаторов и технологических вспомогательных средств", ГОСТ Р 53598-2009 «Продукты пищевые. Рекомендации по этикетированию»

   Состав: cuttings from semi-finished cakes and pastries, white sugar, water, butter (pasteurized cow's milk cream), melange, flour, premium, molasses or glucose syrup, fresh whole milk the weight ratio of fat 3.2%, whole condensed milk with sugar the weight ratio of fat 8.5% (normalized milk, sugar (sucrose, lactose)), raw egg white, cognac or dessert wine, raising agent - ammonium carbonate, cocoa powder, thickener - agar, acidity regulator - citric acid, essence, vanilla powder, citrus essence, raising agent - sodium hydrogen carbonate, essence of rum, cognac, wine.

   Состав: cuttings from semi-finished cakes and pastries, white sugar, water, butter (pasteurized cow's milk cream), melange, flour, premium, molasses or glucose syrup, fresh whole milk the weight ratio of fat 3.2%, whole condensed milk with sugar the weight ratio of fat 8.5% (normalized milk, sugar (sucrose, lactose)), raw egg white, cognac or dessert wine, raising agent - E503(i), cocoa powder, thickener - E406, acidity regulator - E330, essence, vanilla powder, citrus essence, raising agent - E500(ii), essence of rum, cognac, wine.

8. Контроль производства

   На протяжении всего технологического процесса производства кондитерского изделия Butterfly cake [Voskresensk] проводят контроль за соблюдением технологических параметров, качества используемого сырья, материалов, готовой продукции. Готовый продукт подлежит выборочному контролю качества, с записью результатов в журнал.

9. Требования безопасности производства

   Технологический процесс должен соответствовать требованиям техники безопасности и типовым инструкция по охране труда для работников предприятий торговли и общественного питания.

Приложение

Перечень нормативных документов

• Sign up
• ГОСТ 16280-2002 Agar food. Technical conditions.
• Sign up
• ГОСТ 26574-2017 Wheat baking flour. Technical conditions
• Sign up
• ГОСТ 31450-2013 Drinking milk. Technical conditions
• Sign up
• ГОСТ 31726-2012 Food additives. Anhydrous citric acid E330. Technical conditions
• Sign up
• ГОСТ 32261-2013 Butter. Technical conditions
• Sign up
• ГОСТ 33222-2015 Sugar is white. Technical conditions
• Sign up
• ГОСТ 33917-2016 Starch syrup. General specifications
• Sign up
• ГОСТ Р 52195-2003 Flavored wines. General specifications
• Sign up
• СанПиН 1.2.3685-21 "Hygienic standards and requirements for ensuring the safety and (or) harmlessness to humans of environmental factors"
• Sign up