1. Вводная часть

   Настоящая технологическая инструкция распространяется на производство изделия Cake Biryusinka [Noginsk].

2. Характеристика готовой продукции

   Качество изделия Cake Biryusinka [Noginsk] должно соответствовать требованиям .

3. Входной контроль сырья

   Получение и контроль входящего сырья на производство, необходимо проверить:

   • наличие медицинской книжки у водителя,
   • температурный режим и состояния кузова,
   • сопроводительные документы (накладная, декларация, качественное удостоверение).
4. Сырье, применяемое при изготовлении изделия
   1. Перечень сырья
      • Sign up
      • jam
      • butter
      • molasses or glucose syrup
      • melange
      • Sign up
      • whole condensed milk with sugar the weight ratio of fat 8.5%
      • chocolate glaze
      • flour, premium
      • raw egg white
      • Sign up
      • cocoa powder
      • agar
      • citric acid
      • citrus essence
      • Sign up
      • vanilla powder

      Допускается взаимозаменяемость сырья в соответствии с утвержденными указаниями к рецептурам по взаимозаменяемости сырья.

   2. Характеристика сырья

      Sign up

      Jam
      

      Butter
      Butter made from cow's milk and/or dairy products and by-products of milk processing, intended for direct consumption, culinary purposes and use in other food industries. Taste and smell: expressed or insufficiently expressed creamy and aftertaste of pasteurization, without extraneous aftertastes and smells. Consistency: dense, plastic, homogeneous, shiny or slightly matte on the cut. Color: from light yellow to yellow, uniform throughout the mass.

      Molasses or glucose syrup
      Depending on the carbohydrate composition, molasses are divided into the following types: low-sugar, caramel acid, caramel enzymatic, maltose, high-sugar. Appearance: thick viscous liquid. It should be transparent, opalescence is allowed for low-sugar and caramel acidic. Taste and smell: Characteristic of molasses, without foreign taste and smell. Mass fraction of reducing substances in terms of dry matter (glucose equivalent) for low-sugar 26-35%, caramel 36-44%, maltose 38-70%, high-sugar more than 45%. The acidity of low-sugar and caramelized acid syrup obtained from potato and other types of tuber starch is not more than 27 degrees, from corn and other types of grain starch is not more than 15 degrees. At the request of the consumer, the mass fraction of molasses dry matter is allowed less than 78%.

      Melange
      Melange should be dark orange when frozen and light yellow to light orange after thawing. There should be no foreign smells and tastes.

      Sign up

      Whole condensed milk with sugar the weight ratio of fat 8.5%
      Taste and smell: The taste is sweet, clean with a pronounced taste and smell of pasteurized milk without foreign tastes and odors. Slight fodder flavor is allowed. Appearance and consistency: Homogeneous, viscous throughout the mass without the presence of organoleptically perceptible crystals of milk sugar (lactose). A mealy consistency and a slight lactose sediment at the bottom of the package during storage are allowed. Color: White with a cream shade. Uniform throughout the mass.

      Chocolate glaze
      

      Flour, premium
      Wheat flour. The color of the higher grades of flour should be white with a yellowish tinge, the lower ones - whiter, darker and non-uniformly variegated. Flour should taste slightly sweet. When chewing flour, there should be no crunch on the teeth, no bitterness and no odors. Flour moisture - no more than 15%.

      Raw egg white
      The egg white should be whitish fawn to yellow-green when frozen and fawn after thawing. There should be no foreign smells and tastes.

      Sign up

      Cocoa powder
      Finely ground cocoa cake, remaining after partial removal of butter from the cocoa mass, with the addition of various flavors and aromas. Appearance: finely divided, homogeneous powder from light to dark brown. Dull gray tint is not allowed. Taste and aroma are characteristic of cocoa powder: pleasant, bitter, well-expressed, without foreign tastes and odors.

      Agar
      

      Citric acid
      Colorless crystals or white powder without lumps. The taste should be sour, without any foreign aftertaste. There is no smell. The structure should be free-flowing and dry, not sticky to the touch. Mechanical impurities are not allowed.

      Citrus essence
      

      Sign up

      Vanilla powder
      

   3. Хранение сырья

      Все сырье и полуфабрикаты, поступающие на склады предприятия, должны соответствовать требованиям действующей НД, сопровождаются документом, удостоверяющим их качество и безопасность, а так же маркировочным ярлыком на каждом тарном месте (ящике, фляге, коробке) с указанием даты изготовления, срока годности или срока хранения.

      На предприятиях должны соблюдаться требования, предъявляемые к хранению продуктов, предотвращающие их порчу.

      Поступившие в производство продукты перекладывают в чистую промаркированную в соответствии с видом продукта производственную тару или хранят в таре поставщика.

      Продукты хранят согласно принятой классификации по условиям хранения.

      Аллергеносодержащее сырье храниться отдельно.

   4. Подготовка сырья к пуску в производство

      Sign up

      Jam
      

      Butter
      When unpacking, it is carefully checked for the absence of foreign objects. The surface of the oil is cleaned in a special room on metal tables. Stands up to a temperature of 8-10 degrees. C. Before use, the oil is cut into pieces and carefully examined. Intra-workshop transportation of unpacked oil is carried out in a clean, closed production container. It is allowed to use oil strippings in the manufacture of baked products. If the fats are used in melted form, then they are filtered through a metal sieve with a mesh size of 1.5 mm.

      Molasses or glucose syrup
      Starch syrup is heated to 40 -50 ℃ to reduce the viscosity, and then filtered through a sieve with cells of no more than 2 mm.

      Melange
      Before being fed into production, frozen melange is pre-thawed in baths with water or special chambers at a temperature not exceeding 45 ℃ and filtered through a sieve with a mesh size of not more than 3 mm. For products in which whole milk or water is used when kneading the dough, the melange can be mixed with them in a 1: 1 ratio before straining. Thawed egg products should be used within 3-4 hours.

      Sign up

      Whole condensed milk with sugar the weight ratio of fat 8.5%
      Condensed milk is freed from the transport container before being used in production and unpacked and fed to the boiling section, where it is loaded into the digester and heated to a temperature of 85 ℃ for 15-20 minutes. After processing, the condensed milk is filtered through a sieve with cells of no more than 3 mm in diameter. The filtered and cooled condensed milk is placed in clean, dry, labeled containers with tight-fitting lids. Moving in the production of condensed milk in open containers and without marking is prohibited.

      Chocolate glaze
      

      Flour, premium
      Wheat flour is sifted through a sieve with meshes of not more than 2.5 mm and passed through magnetic catchers. If the flour is at a low temperature, then it should be kept in a warm room so that the temperature rises to 12 ℃.

      Raw egg white
      Before use, filter the egg white through a sieve with a mesh size of not more than 3 mm.

      Sign up

      Cocoa powder
      Sieve through a sieve with cells of 1-1.5 mm.

      Agar
      Agar is soaked in running water for 2-4 hours.

      Citric acid
      Dissolve citric acid in hot water (70-80 в) in a 1: 1 ratio and filter through a sieve with cells of no more than 0.5 mm.

      Citrus essence
      

      Sign up

      Vanilla powder
      

5. Описание технологического процесса
   1. Описание процесса изготовления полуфабрикатов:

      Sign up

      # 099 Lipstick
      

      Granulated sugar and water in a ratio of 3: 1 are brought to a boil in an open kettle with stirring, removing the resulting foam. Then close the cauldron with a lid, boil the syrup to a temperature of 108 ℃ and add molasses heated to 50 ℃, then boil it down to a temperature of 115-117 ℃ (test for a weak ball). At the end of cooking, add the essence.
      Hot syrup is poured in a layer of 20–30 mm on a table with marble chips and cooled to 35–45 ℃ for 40–45 minutes. Chilled syrup is whipped on a beater for 15-20 minutes or manually on the table using a spatula.

      ** Characteristics of a semi-finished product. ** Homogeneous, plastic, glossy white mass.

      Sign up

      No. 098 Sugar-agar syrup
      

      Granulated sugar and water in a ratio of 4: 1 are boiled to a temperature of 120 ℃, agar is added, previously soaked in running water for 3-4 hours, heated over low heat with stirring until the agar is completely dissolved and molasses is added, after which the syrup is heated to 118 ℃.

      Sign up

      №105 Souffle
      

      Hot sugar-agar syrup is introduced in a thin stream into the egg whites, beaten for 15–20 minutes, and beating is continued until a fluffy mass is obtained.
      At the end of whipping, add a prepared homogeneous mixture of softened butter, condensed milk, citrus essence and stop whipping immediately.

      ** Characteristics of a semi-finished product. ** A thick, fluffy mass of white color, well retaining its shape.

   2. Приготовление кондитерского изделия:

      Sign up

6. Упаковка

7. Mаркировка, транспортирование и хранение

   Маркировка готовых изделий должна соответствовать Техническим регламентам Таможенного союза ТР ТС 022/2011 «Пищевая продукция в части ее маркировки», ТР ТС 029/2012 "Требования безопасности пищевых добавок, ароматизаторов и технологических вспомогательных средств", ГОСТ Р 53598-2009 «Продукты пищевые. Рекомендации по этикетированию»

   Состав: white sugar, jam, butter (pasteurized cow's milk cream), molasses or glucose syrup, melange, water, whole condensed milk with sugar the weight ratio of fat 8.5% (normalized milk, sugar (sucrose, lactose)), chocolate glaze, flour, premium, raw egg white, potato starch, cocoa powder, thickener - agar, acidity regulator - citric acid, citrus essence, essence, vanilla powder.

   Состав: white sugar, jam, butter (pasteurized cow's milk cream), molasses or glucose syrup, melange, water, whole condensed milk with sugar the weight ratio of fat 8.5% (normalized milk, sugar (sucrose, lactose)), chocolate glaze, flour, premium, raw egg white, potato starch, cocoa powder, thickener - E406, acidity regulator - E330, citrus essence, essence, vanilla powder.

8. Контроль производства

   На протяжении всего технологического процесса производства кондитерского изделия Cake Biryusinka [Noginsk] проводят контроль за соблюдением технологических параметров, качества используемого сырья, материалов, готовой продукции. Готовый продукт подлежит выборочному контролю качества, с записью результатов в журнал.

9. Требования безопасности производства

   Технологический процесс должен соответствовать требованиям техники безопасности и типовым инструкция по охране труда для работников предприятий торговли и общественного питания.

Приложение

Перечень нормативных документов

• Sign up
• ГОСТ 16280-2002 Agar food. Technical conditions.
• Sign up
• ГОСТ 30363-2013 Liquid and dry food egg products. Technical conditions
• Sign up
• ГОСТ 31726-2012 Food additives. Anhydrous citric acid E330. Technical conditions
• Sign up
• ГОСТ 32261-2013 Butter. Technical conditions
• Sign up
• ГОСТ 33917-2016 Starch syrup. General specifications
• Sign up
• ГОСТ Р 53876-2010 Potato starch. Technical conditions
• Sign up
• СанПиН 1.2.3685-21 "Hygienic standards and requirements for ensuring the safety and (or) harmlessness to humans of environmental factors"
• Sign up