_____________
'___' ______________ 2024г.
по производству изделия
№180 "Golden Ring"
Вырабатывается по ГОСТ 4570-2014
- Вводная часть
Настоящая технологическая инструкция распространяется на производство изделия №180 "Golden Ring".
- Характеристика готовой продукции
Качество изделия №180 "Golden Ring" должно соответствовать требованиям ГОСТ 4570-2014.
- Входной контроль сырья
Получение и контроль входящего сырья на производство, необходимо проверить:
- наличие медицинской книжки у водителя,
- температурный режим и состояния кузова,
- сопроводительные документы (накладная, декларация, качественное удостоверение).
- Сырье, применяемое при изготовлении изделия
- Перечень сырья
- Sign up
- chocolate glaze
- whole condensed milk with sugar the weight ratio of fat 8.5%
- blackcurrant puree
- plum puree
- Sign up
- cognac
- molasses or glucose syrup
- alcohol
- apple pectin
- Sign up
- vanillin
Допускается взаимозаменяемость сырья в соответствии с утвержденными указаниями к рецептурам по взаимозаменяемости сырья.
- Характеристика сырья
Chocolate glaze
Whole condensed milk with sugar the weight ratio of fat 8.5%
Taste and smell: The taste is sweet, clean with a pronounced taste and smell of pasteurized milk without foreign tastes and odors. Slight fodder flavor is allowed. Appearance and consistency: Homogeneous, viscous throughout the mass without the presence of organoleptically perceptible crystals of milk sugar (lactose). A mealy consistency and a slight lactose sediment at the bottom of the package during storage are allowed. Color: White with a cream shade. Uniform throughout the mass.Blackcurrant puree
Plum puree
Cognac
Molasses or glucose syrup
Depending on the carbohydrate composition, molasses are divided into the following types: low-sugar, caramel acid, caramel enzymatic, maltose, high-sugar. Appearance: thick viscous liquid. It should be transparent, opalescence is allowed for low-sugar and caramel acidic. Taste and smell: Characteristic of molasses, without foreign taste and smell. Mass fraction of reducing substances in terms of dry matter (glucose equivalent) for low-sugar 26-35%, caramel 36-44%, maltose 38-70%, high-sugar more than 45%. The acidity of low-sugar and caramelized acid syrup obtained from potato and other types of tuber starch is not more than 27 degrees, from corn and other types of grain starch is not more than 15 degrees. At the request of the consumer, the mass fraction of molasses dry matter is allowed less than 78%.Alcohol
Apple pectin
Appearance: Fine powder without foreign impurities. The presence of a fibrous fraction of pectin in the form of flakes is allowed / Taste: Slightly acidic. Odor: None. Color: Light gray to cream.Vanillin
- Хранение сырья
Все сырье и полуфабрикаты, поступающие на склады предприятия, должны соответствовать требованиям действующей НД, сопровождаются документом, удостоверяющим их качество и безопасность, а так же маркировочным ярлыком на каждом тарном месте (ящике, фляге, коробке) с указанием даты изготовления, срока годности или срока хранения.
На предприятиях должны соблюдаться требования, предъявляемые к хранению продуктов, предотвращающие их порчу.
Поступившие в производство продукты перекладывают в чистую промаркированную в соответствии с видом продукта производственную тару или хранят в таре поставщика.
Продукты хранят согласно принятой классификации по условиям хранения.
Аллергеносодержащее сырье храниться отдельно.
- Подготовка сырья к пуску в производство
Chocolate glaze
Whole condensed milk with sugar the weight ratio of fat 8.5%
Condensed milk is freed from the transport container before being used in production and unpacked and fed to the boiling section, where it is loaded into the digester and heated to a temperature of 85 ℃ for 15-20 minutes. After processing, the condensed milk is filtered through a sieve with cells of no more than 3 mm in diameter. The filtered and cooled condensed milk is placed in clean, dry, labeled containers with tight-fitting lids. Moving in the production of condensed milk in open containers and without marking is prohibited.Blackcurrant puree
Plum puree
Cognac
Molasses or glucose syrup
Starch syrup is heated to 40 -50 ℃ to reduce the viscosity, and then filtered through a sieve with cells of no more than 2 mm.Alcohol
Apple pectin
Vanillin
- Перечень сырья
- Описание технологического процесса
- Упаковка
- Mаркировка, транспортирование и хранение
Маркировка готовых изделий должна соответствовать Техническим регламентам Таможенного союза ТР ТС 022/2011 «Пищевая продукция в части ее маркировки», ТР ТС 029/2012 "Требования безопасности пищевых добавок, ароматизаторов и технологических вспомогательных средств", ГОСТ Р 53598-2009 «Продукты пищевые. Рекомендации по этикетированию»
Состав: white sugar, chocolate glaze, whole condensed milk with sugar the weight ratio of fat 8.5% (normalized milk, sugar (sucrose, lactose)), blackcurrant puree, plum puree, butter (pasteurized cow's milk cream), cognac, molasses or glucose syrup, alcohol, gelling agent - apple pectin, acidity regulator - citric acid, vanillin.
Состав: white sugar, chocolate glaze, whole condensed milk with sugar the weight ratio of fat 8.5% (normalized milk, sugar (sucrose, lactose)), blackcurrant puree, plum puree, butter (pasteurized cow's milk cream), cognac, molasses or glucose syrup, alcohol, gelling agent - E440, acidity regulator - E330, vanillin.
- Контроль производства
На протяжении всего технологического процесса производства кондитерского изделия №180 "Golden Ring" проводят контроль за соблюдением технологических параметров, качества используемого сырья, материалов, готовой продукции. Готовый продукт подлежит выборочному контролю качества, с записью результатов в журнал.
- Требования безопасности производства
Технологический процесс должен соответствовать требованиям техники безопасности и типовым инструкция по охране труда для работников предприятий торговли и общественного питания.
Приложение
Перечень нормативных документов